LUBRICATION/SERVICES NOTES - TM-9-2320-366-20-21478

TM 9-2320-366-20-2

H-8. LOCAL VIEWS (CONT)

H-9. LUBRICATION/SERVICES NOTES

1. ENGINE CRANKCASE. Check engine oil level daily. Change engine oil at initial 5,000 miles (8,045 km).

During the remainder of the 12,000 mile (19,308 km)/18 month warranty period. Units participating in AOAP will

sample engine oil every 3,000 miles (4,827 km) or 6 months, whichever occurs first and change oil as directed by

AOAP. Units not participating in AOAP, will change engine oil every 6,000 miles (9,654 km) or every six months,

whichever occurs first. After expiration of engine warranty period, Units participating in AOAP will perform engine oil

change as directed by AOAP. Units not participating in AOAP will change engine oil every 6,000 miles (9,654 km) or

every six months, whichever occurs first, or when operating in dusty areas or under severe operating conditions,

change the oil every 3,000 miles (4,827 km) or every three months, whichever occurs first. Drain engine oil when

engine is warm. Refill engine crankcase with OE/HDO specified for the ambient temperature. Engine oil is full when

level is within crosshatch marks on the dipstick. Do not overfill.

2. ENGINE OIL FILTER. Filter is replaced each time the crankcase is drained. If water or metal particles are

detected during oil filter replacement, notify Direct Support Maintenance personnel before refilling crankcase (para 3-

4).

3. TRANSMISSION. Check transmission oil level daily. Change transmission oil at initial 5,000 miles (8,045 km).

During the remainder of the 24 month/unlimited mileage warranty. Units participating in AOAP will sample

transmission oil every 6,000 miles (9,654 km) or 12 months, whichever occurs first and change oil as directed by

AOAP. Units not participating in AOAP will perform transmission oil change every 24,000 miles (38,616 km) or once

every two years, whichever occurs first. Drain transmission oil when engine is warm. Refill with OE/HDO specified

for ambient temperature. Add oil until the proper level is reached (TM 9-2320-366-10-1). Do not overfill. Replace

oil filters each time transmission oil is changed (para 8-9).

4. POWER STEERING. Check power steering oil level weekly. Change the oil every 24,000 miles (38,616 km).

Disconnect upper and lower hoses from steering gear and drain oil. Refill power steering pump reservoir with

OE/HDO specified for the ambient temperature. Reservoir is full when oil is between the two marks on the dipstick.

Do not overfill. Remove dipstick, wipe clean and install dipstick fully into reservoir. Remove dipstick and read oil

level. Replace oil filter each time power steering oil is changed (para 13-8).

H-26

Change 2